There are many matters for attention in the safe operation of electric stackers

There are many matters for attention in the safe operation of electric stackers
The following are some useful suggestions .
1. The operator of the electric stacker is not allowed to drive after drinking, overweight, super high or speeding, and it is forbidden to brake or turn sharply. It is forbidden to enter the places where solvents and combustible gases are stored.
2. The safety device of the electric stacker must be complete and intact, with sensitive and effective components and good technical performance. It is strictly prohibited to drive the stacker with illness.
3. Keep the standard driving state of the stacking, when the fork is off the ground, the fork is 10-20 cm off the ground. When the stacker stops, it drops to the ground and drives around in poor road conditions, its weight should be properly reduced, and the speed of the stacking should be reduced.
4. When the electric stacker is running, if the electric controller is out of control, disconnect the main power supply in time.
5. Special attention should be paid to the timely charging of the battery and the correct maintenance of the battery in the use of the electric stacker. Battery charging should pay attention to the method, not only to make the battery sufficient electricity, but also can not cause the battery overcharging.
6. In the operation of electric stacker, use as little as possible to accelerate for a long time and a long distance. When the stacker starts and the speed increases, keep the accelerator pedal steady. When the stacker needs to slow down, relax the accelerator pedal and gently press the brake pedal, so as to make full use of the deceleration energy. If the stacker has regenerative braking function, the kinetic energy during deceleration can be recovered. When the vehicle is going down the ramp, do not disconnect the driving motor circuit of the stacker car, gently press the brake pedal, so that the stacker car can operate in the regenerative braking state, and use the kinetic energy of the vehicle going down to reduce the energy consumption of the battery.
7. In the operation of electric stacker, do not mistake the direction switch of “forward and backward” as the steering switch. Do not press the brake pedal directly to the end unless you need to slow down in an emergency. During the use of the vehicle, when the battery power is found to be insufficient (which can be obtained through the electricity meter, power deficit indicator light and other alarm devices), the battery should be charged as soon as possible to prevent excessive discharge of the battery.
8.Electric stacker operation, do not in the process of high-speed driving, often take emergency braking; Otherwise, it will cause huge friction to the brake assembly and driving wheel, shorten the service life of the brake assembly and driving wheel, and even damage the brake assembly and driving wheel.